• 1
  • 2

Choosing and using a base layer to stay co…

Choosing and using a base layer to stay comfortable

A great number of people I speak to seem to be baffled by the use of a base layer, either they have not experienced one or are under some misconceptio. Read more

Bridgestone Battlax S20 Tyre - First Ride

Bridgestone Battlax S20 Tyre - First Ride

Bridgestone have got a new trick up their sleeve, the new Hypersport street tyre that replaces the outgoing BT-016 range which was received with a mix. Read more

Keep motorcycle insurance costs low

Keep motorcycle insurance costs low

Life on two wheels has quite a few advantages over driving a car - among them lower fuel consumption and cheaper cover from providers like MCE bike in. Read more

Apathy will bring the end of motorcycling …

Apathy will bring the end of motorcycling as we know it

The recent uproar about upcoming E.U. regulations to ban users from modifying a motorcycle from standard has certainly brought a few ideas to the surf. Read more

Pipe-Werx Exhausts bring us the very best …

Pipe-Werx Exhausts bring us the very best of British

It's the middle of summer, August in fact, and the weather is supposed to be glorious which has led me to contact Pipe-Werx of Lathom to have a look a. Read more

Motorcycling as an older lady rider

Motorcycling as an older lady rider

At the grand old age of 40 I decided that I had had enough of my other half sitting me on bikes in the local bike shops to see which one was right for. Read more

How crash protection is made at GBRacing

How crash protection is made at GBRacing

Cold, wet and fresh out of bed, I wheel my trusty bike out onto the road and thumb the starter, at 6am this is far from my normal riding time but toda. Read more

Metzeler Interact Tyres back to back - roa…

Metzeler Interact Tyres back to back - road and track

Cold, wet and foggy, I am sat in the departure lounge at Manchester Airport at 4am awaiting a flight to Alicante in Spain and the start of my part in . Read more

How I did the Iron Butt for the Royal Brit…

How I did the Iron Butt for the Royal British legion - wanna come?

Do you ever get the feeling that some things seem a good idea at the time?, this was one of those moments. A neighbour and Royal British Legion member. Read more

01RaceFX have race bikes all wrapped up

01RaceFX have race bikes all wrapped up

Having seen a few photo's of what the guys over at 01RaceFX get up to my interest was well and truly piqued, the application of race bike livery on ro. Read more

Tuesday, 30 June 2009 14:13

How to setup your suspension

Written by 
Ohlins rear shock for suspension setup Ohlins rear shock for suspension setup Ohlins and Good-win-racing

Things You'll Need:

* Motorcycle (this article assumes you are riding a sportbike)
* A couple of friends to help is nice, one at minimum
* Paper and pencil to write down the numbers
* A ruler that measure in metric (millimeters)


1.
Step 1

RIDER SAG is the distance the suspension compresses under the weight of the rider on the bike, in gear, in the riding position. The objective is to set (for both the rear suspension and the front suspension) the spring/shock preload so that we have the optimal Rider Sag. In addition, we want an optimal FREE SAG, which is the distance the suspension compresses under the weight of the bike alone, without any rider. Finally, we want to measure STICTION, which is the variance in suspension compression that is attributable to friction of the suspension components. If the idea of stiction sounds confusing, read on and it will be very clear once you take the measurements.
2.
Step 2

REAR SUSPENSION: Begin with the rear suspension. First you need to measure Full extension. Without a center stand, you must support the bike by the rearsets or have your helpers lift the bike. You want for the bike’s swingarm to fall and extend freely and fully. Then, measure from a specific point on your axel nut to a specific point on your subframe or rear body work. Have the same person measure each time, and be very precise. Maybe put a piece of tape on the tail above the axel and mark a line on it so that you can measure from this same point. If your body work is race plastics and is a bit flimsy, try to find a place on the subframe instead. You want your measurements to be very accurate. Always have the same person take each measurement (to ensure consistency).
3.
Step 3

Measuring Rear Sag

Next, you need to measure rear suspension Free Sag, which is the sag of the bike under its own weight. If you were to simply stand up the bike and measure it, you would get inconsistent numbers because the rear suspension would settle in slightly different positions each time. This is due to the stiction in the suspension. To account for stiction, you must take two measurements and average the two. First, with the bike resting on its own weight and someone supporting it in the front to keep it level, press down very hard on the rear and let it rise up VERY slowly/gently until it settles. Take a measurement once it settles. Next, lift up on the tail and then let it settle back down VERY slowly and gently. Measure again in this position. Average these two to get your Free Sag. The difference between your two measurements is the rear suspension stiction. If the stiction is more than about 5mm on the rear, that's too much stiction and you should have the suspension serviced.
4.
Step 4

Finally, you need to measure rear suspension Rider Sag. This is done just like you measured Free Sag, but with you sitting on the bike (in full gear, in an agressive riding position). Again, someone must support the front. Then have your helper that is taking the measurements take the two measurements to account for stiction. Follow the same procedure as you did for Free Sag. Again, be very precise.
5.
Step 5

Click for Example

Click image for example numbers. For the rear suspension, these are numbers you want to see... ~5-10mm Free Sag and ~30mm Rider Sag. Of course, your actual measurements will differ, but that's the type of sag you want to see, in the end.
6.
Step 6

To adjust your Rider Sag, vary the shock preload by turning the large coupler that presses against the rear shock spring. You will probably need a special tool to turn this coupler, and it will require considerable force since the spring is under a lot of pressure.
7.
Step 7

Measuring Front Sag

FRONT SUSPENSION: On your front forks, it's the same process. You'll want to measure from a fixed point on the fork (for USF, or upside-down forks) or the steering head. Use tape to mark a line, if it helps. And measure very precisely, just as you did for the rear.
8.
Step 8

Using Calipers on USF

For USF front ends, you can also use a set of calipers to just measure the inner fork tube (shiny chrome area) on the fork. This is the easiest place to mesure if you have USF forks.
9.
Step 9

For the front forks, you are shooting for ~15-20mm Free Sag and ~35mm Rider Sag.
10.
Step 10

To adjust your Rider Sag on the front, vary the fork preload by turning the large nuts on the top of each fork tube. Be sure you adjust each tube in the same direction by the same amount. Don’t worry if it’s not EXACTLY the same, but try to keep them equivalent.
11.
Step 11

Regarding stiction on the front, we’re told by the suspension gurus that anything >10mm is a red flag. Note that this is for Free Sag stiction. When measuring Rider Sag, and the fork is more compressed, you’ll likely see more stiction, and that’s okay.

Read 4837 times
More in this category: Top 5 bike care tips »

arc-on Evolution Leather Suit and Gloves

arc-on Evolution Leather Suit and Gloves

Over at arc-on the previous seasons suits have seen a redesign and launch in the form of the Evolution suit, available in one or two piece formats, and the new Evolution glove to match. Previous years experience in racing have given them a decent spec sheet to sing from, even if you name is not one that you have seen before, considering that a load.

Read more

Recent Equipment Reviews

Reviewed by You! - Visit any product and leave your own feedback

Knox Handroid Gloves - Review
 
9.7
Spada Elite Gloves - Review
 
9.7
Knox Handroid Gloves - Review
 
4.3
Spada ST1 Boots - Review
 
8.6
Knox Handroid Gloves - Review
 
9.5
Arai Quantum Helmet - Review
 
6.5

Currently Under Review

Alpinestars GP Pro Suit
Dobeck Gen3.5 EJK
Knox K-Pack
DP Race Clutch
GoPro HD Hero
Garmin Zumo 220
Forcefield Pro Sub 4
Metzeler Sportec M5
Skins A400 Compression Tights
DP Sintered Brake Pads
Skins A400 Compression Top
Draggin Next Gen jeans